Cat trouble codes

Discussion in 'Trucks [ Eighteen Wheelers ]' started by underpsi, Feb 5, 2009.

  1. pichu

    pichu Light Load Member

    103
    19
    Jan 18, 2009
    mexifornia
    0
    2 MID 128 - CAT MID 128 - CAT CAT PID/ SID FMI Fault Code Fault Description 1 11 72 Cylinder 1 Fault 2 11 72 Cylinder 2 Fault 3 11 73 Cylinder 3 Fault 4 11 73 Cylinder 4 Fault 5 11 74 Cylinder 5 Fault 6 11 74 Cylinder 6 Fault 22 13 42 Check Timing Sensor Calibration 30 8 29 Invalid PTO Throttle Signal 13 29 PTO Throttle Sensor Calibration 41 3 21 Volt Supply Above Normal 4 21 Volt Supply Below Normal 71 0 1 Idle Shutdown Override 1 47 Idle Shutdown Occurrence 84 0 41 Vehicle Over speed Warning 1 31 Loss of Vehicle Speed Signal 2 36 Invalid Vehicle Speed Signal 8 36 Vehicle Speed Out of Range 10 36 Vehicle Speed Rate of Change 91 8 32 Invalid Throttle Signal 13 28 Throttle Sensor Calibration 100 1 46 Low Oil Pressure Warning 3 24 Oil Pressure Sensor Open Circuit 4 24 Oil Pressure Sensor Short Circuit 11 46 Very Low Oil Pressure 102 0 25 Boost Pressure Sensor Stuck High 3 25 Boost Pressure Sensor Open Circuit 4 25 Boost Pressure Sensor Short Circuit 13 42 Boost Pressure Sensor Calibration 105 0 64 High Intake Manifold Air Temp. Sensor Open Circuit 3 38 Intake Manifold Air Temp. Sensor Open Circuit 105 4 38 Intake Manifold Air Temp. Sensor Short Circuit 11 64 Very High Intake Manifold Air Temp 108 3 26 Atmospheric Press. Sensor Open Circuit 4 26 Atmospheric Press. Sensor Short Circuit 110 0 61 High Coolant Temperature Warning 3 27 Coolant Temp Sensor Open Circuit 4 27 Coolant Temp Sensor Short Circuit 11 61 Very High Coolant Temperature 111 1 62 Low Coolant Level Warning 2 12 Coolant Level Sensor Fault 11 62 Very Low Coolant Level 121 5 14 Retarder Solenoid Lo/Hi Open Circuit 6 14 Retarder Solenoid Lo/Hi Short Circuit 122 5 14 Retarder Solenoid Med/Hi Open Circuit 6 14 Retarder Solenoid Med/Hi Short Circuit 168 2 51 Low/Intermittent Battery Power to ECM 174 0 65 High Fuel Temperature Warning 3 13 Fuel Temperature Sensor Open Circuit 4 13 Fuel Temperature Sensor Short Circuit 190 0 35 Engine Over speed Warning 2 34 Loss of Engine RPM Signal 228 3 19 A/C High Pressure Switch Open Circuit 231 11 58 J1939 Data Link Fault 232 3 21 Volt Supply Above Normal 4 21 Volt Supply Below Normal 244 2 2 Event Recorder Data Lost 249 11 58 Power train Data Link Fault 252 11 59 Incorrect Engine Software 12 59 Personality Module Fault 253 2 56 Check Customer or System Parameters 254 12 53 ECM FaultFlash Code Code Description of Code
    00 52-11 Air Inlet Shutoff Shutdown
    84-14 Quick Stop Occurrence
    171-03 Ambient Air Temperature voltage high
    171-04 Ambient Air Temperature voltage low
    171-11 Ambient Air Temperature Data Lost
    224-11 Theft Deterrent Active
    224-14 Theft Deterrent Active with Engine Cranking
    246-11 Brake Pedal Switch #1 Fault
    247-11 Brake Pedal Switch #2 Fault

    01 71-00 Idle Shutdown Override

    12 111-02 Coolant Level signal invalid
    111-03 Coolant Level voltage high
    111-04 Coolant Level voltage low

    13 174-03 Fuel Temperature voltage high
    174-04 Fuel Temperature voltage low

    14 121-05 Low/High Retarder current low
    121-06 Low/High Retarder current high
    122-05 Med/High Retarder current low
    122-06 Med/High Retarder current high

    21 41-03 8 Volt Supply voltage high
    41-04 8 Volt Supply voltage low
    232-03 5 Volt Supply voltage high
    232-04 5 Volt Supply voltage low

    24 100-03 Oil Pressure voltage high
    100-04 Oil Pressure voltage low

    25 102-00 Excessive Boost Pressure
    102-03 Boost Pressure voltage high
    102-04 Boost Pressure voltage low

    26 108-03 Barometric Pressure voltage high
    108-04 Barometric Pressure voltage low

    27 110-03 Coolant Temperature voltage high
    110-04 Coolant Temperature voltage low

    28 91-13 Throttle Sensor Calibration

    29 30-08 PTO Throttle signal invalid

    30-13 PTO Throttle out of calibration

    31 84-01 Vehicle Speed loss of signal

    32 91-08 Throttle Position Invalid

    34 64-12 Secondary Engine Speed loss of signal
    190-12 Primary Engine Speed loss of signal

    35 190-00 Engine Overspeed Warning

    36 84-02 Vehicle Speed signal invalid
    84-08 Vehicle Speed signal out of range
    84-10 Vehicle Speed signal rate of change

    38 105-03 Intake Manifold Air Temperature voltage high
    105-04 Intake Manifold Air Temperature voltage low

    41 84-00 Vehicle Overspeed Warning

    42 22-11 Primary to Secondary Engine Speed Signal Calibration
    22-13 Engine Speed Signal Calibration Not Performed

    46 100-01 Low Oil Pressure Warning
    100-11 Very Low Oil Pressure

    47 71-01 Idle Shutdown
    71-14 PTO Shutdown

    51 168-02 ECM Battery Power Intermittent

    55 N/A No Diagnostic Code Detected

    56 253-02 Check Customer or System Parameters
    253-11 Check Transmission Customer Parameters

    58 231-11 J1939 Data Link Fault
    249-11 J1922 Data Link Fault

    59 252-11 Engine Software Incorrect

    61 110-00 High Coolant Temperature Warning
    110-11 Very High Coolant Temperature

    62 111-01 Low Coolant Level Warning
    111-11 Very Low Coolant Level

    64 105-00 High Intake Manifold Air Temperature Warning
    105-11 Very High Intake Manifold Air Temperature

    65 174-00 High Fuel Temperature Warning

    66 54-05 Auxiliary Output #06 current low
    54-06 Auxiliary Output #06 current high

    67 55-05 AuxiliaryOutput #07 current low
    55-06 Auxiliary Output #07 current high

    68 191-07 Transmission Not Responding

    71 43-02 Key Switch Fault

    72 1-11 Cylinder #1 Injector current fault
    2-11 Cylinder #2 Injector current fault

    73 3-11 Cylinder #3 Injector current fault
    4-11 Cylinder #4 Injector current fault

    74 5-11 Cylinder #5 Injector current fault
    6-11 Cylinder #6 Injector current fault
     
  2. Truckers Report Jobs

    Trucking Jobs in 30 seconds

    Every month 400 people find a job with the help of TruckersReport.

  3. rdelease

    rdelease Bobtail Member

    1
    0
    Mar 8, 2011
    Wartrace TN
    0
    Does anyone know what engine code SID032 means for a cat engine c-15?
     
  4. owensno

    owensno Bobtail Member

    2
    0
    Jul 6, 2011
    midland texas
    0
    Does anyone have possible causes for fault code 151 Igntion Key Switch Fault?
     
  5. little cat 500

    little cat 500 Road Train Member

    1,949
    1,004
    Jan 17, 2010
    Abbottstown PA
    0
    i have code 25 then a pause the 8 not sure what i have here
     
  6. boatrace

    boatrace Bobtail Member

    1
    0
    Aug 21, 2011
    land o lakes fl
    0
    what good numbers for econ and power 3406e 550
     
  7. markk

    markk Medium Load Member

    566
    195
    Nov 14, 2011
    0
    What if it blinks 1 time every 5 seconds ?
    low power . loses 15 or 20 miles an hour up a hill as opposed to when it is not flashing . does not store a code . restart engine , truck runs normally for a while

    thanks
     
  8. 1charger

    1charger Bobtail Member

    1
    0
    Nov 8, 2011
    vineland nj
    0
    2006 ftl classic c15 code 95,temp below 120, engine light blinking engine shuts off
    T/A tech says intake valve actuation system oil press volt high ???
     
  9. DDS

    DDS Medium Load Member

    519
    177
    May 20, 2008
    Toronto
    0
    Common sensor to fail, its easy to change, right side top of engine by the front valve cover. May be a wiring harness but I would just plug a sensor in and go from there. The sensor has been updated by Cat a few time due to design flaws.

    The running cold problem is water regulators or the coolant diverter valve is stuck open.
     
  10. Javaman

    Javaman Bobtail Member

    3
    0
    Mar 10, 2012
    Fresno, CA
    0
    I've got a 2000 Freight. FL-70 with a flash code of 15 and have not been able to locate any info about it.
     
  11. dactrucking

    dactrucking Bobtail Member

    10
    0
    Dec 12, 2013
    0
    how do you clear codes
     
  • Truckers Report Jobs

    Trucking Jobs in 30 seconds

    Every month 400 people find a job with the help of TruckersReport.