Volvo power window module repair.

Discussion in 'Volvo Forum' started by Snailexpress, Jan 26, 2021.

  1. Snailexpress

    Snailexpress Road Train Member

    2,654
    6,034
    Apr 28, 2014
    Rocky
    0
    Many Volvo owners (victims) have problem with power window module . Sometime it wont open passenger door or roll windows up or down.
    Volvo OEM part is almost $200. Amazon sell them for $35 - 40 but quality very low.
    Amazon com Power Window Switch For Volvo.png
    Don't worry. You can fix it yourself.
    You need set of screwdrivers from Harbor Freight or similar with ST5 bit. $8
    Solder iron 15 - 20 watt and solder with rosin. Walmart sell it.
    Pry gently module from the front with flat screwdriver, pushing screwdriver in to push the retaining tab on the module.
    PXL_20210127_023224465[1].jpg
    Pull front up and gently work with rear to pull module from the panel.
    Disconnect wire plug pushing retaining tab.
    Unscrew bottom screws with TS5 bit and remove the bottom.
    Now you should see top PCB (printed circuit board) with lot of transistors connected with second PCB by flat flexible wires.
    Gently pull first PCB up and bend flat connector to open access to rear side of the first PCB .
    Do you see how wire connector pins slotted in PCB without soldering? Surprised Volvo went so cheap on electronics.
    Make your solder iron ready, inspect PCB for any signs of overheating or corrosion damage.
    Solder wire plug pins to PCB
    PXL_20210120_231556624[1].jpg
    You almost done.
    Use rubbing alcohol and cotton tip swabs to clean flux residue and PCB. Gate transistors very sensitive for any dirt.
    BTW. Wife or GF tooth brush will work the best.
    After it dry, put everything back as it was, connect wires and install module in the panel.
    Rear side going in first then just push down front.
    Hopefully I help you.
     
  2. Truckers Report Jobs

    Trucking Jobs in 30 seconds

    Every month 400 people find a job with the help of TruckersReport.

  3. Dave_in_AZ

    Dave_in_AZ Road Train Member

    49,754
    315,042
    May 4, 2015
    0
    So put the GF's toothbrush back where it was when finished?
     
    KB3MMX and QUALITYTRUCK Thank this.
  4. Snailexpress

    Snailexpress Road Train Member

    2,654
    6,034
    Apr 28, 2014
    Rocky
    0
    Sure. You don't want to be killed or impeached.
     
    KB3MMX, QUALITYTRUCK and Dave_in_AZ Thank this.
  5. dorlia2

    dorlia2 Light Load Member

    149
    28
    Apr 20, 2012
    DOWNERS GROVE
    0
    What is ST5 bit? Can't seem to find anything that will fit
     
  • Truckers Report Jobs

    Trucking Jobs in 30 seconds

    Every month 400 people find a job with the help of TruckersReport.