I have a 2000 Kenworth W900L with a 12.7 Detroit. I was driving down the driveway and the truck just shut off, I figured I had a direct short somewhere, but all the wires were good. The solenoid was smoking a little, I was able to start the truck and get it back home, I kept looking for a shorted wire but could not find one. Is it possible the starter could have an internal short?
2000 KW W900L Starter Problems
Discussion in 'Heavy Duty Diesel Truck Mechanics Forum' started by Montanajon, Jul 5, 2021.
Page 1 of 2
-
-
Trucking Jobs in 30 seconds
Every month 400 people find a job with the help of TruckersReport.
-
Loose connection more than likely. When it quit, if you lost the dash check engine lights, and buzzer. (Key on, before cranking test mode) Its likely the small ecm ground wire from battery to frame. Take them off, clean the ground wires and the frame. Also check the ecm supply wire from positive on battery , check it good, along with the small 5 amp inline fuse, it might be corroded. That’s IF the dash check engine lights quit working, when it died. Shows a lost ecm connection. Might have just lost connection enough to make it die, and then started working. And dash lights not working wasn’t noticed. Smoking starter, might just be a result of cranking with bad or loose connection. Might be on its way out, or just pulling a high draw when cranking due to a loose connection. Check all connections, starting at batteries. Cleaning everything up, especially the grounds to frame. Then make sure the starter wires are all tight, clean up the ground to frame. And the wire from starter to alternator, making sure it’s not chafed and grounding out. Any other grounds to frame you can find. Shorted battery will cause it to smoke, or jumping it with a shorted battery, loose connections, will cause the starter and batteries to smoke. Don’t think it will cause it to die though. To die, it’s usually the ecm ground wire, or positive wire, or the ecm fuse. Or a broken large cable to the Starter. That’s usually very obvious.
baha Thanks this. -
Check for loose wires on the ignition lock
Rideandrepair Thanks this. -
Rideandrepair Thanks this.
-
Rideandrepair Thanks this.
-
It shut off by itself while moving? That's not a starter problem.
lester, Bean Jr., Rideandrepair and 1 other person Thank this. -
What AModel said... did you even have the starter or batteries tested ???
Or you just replaced them cause they looked oldRideandrepair Thanks this. -
Bean Jr. and Rideandrepair Thank this.
-
Rideandrepair and Montanajon Thank this.
-
BoxCarKidd, Rideandrepair and baha Thank this.
Trucking Jobs in 30 seconds
Every month 400 people find a job with the help of TruckersReport.
Page 1 of 2