I have a volvo vnl d16. I replaced the starter but my truck wont crank. I did a bypass and it starts but it wont shut off. Can anyone help me?
Volvo VNL Starting Issues
Discussion in 'Volvo Forum' started by Volvotruck2019, Aug 7, 2019.
Page 1 of 2
-
-
Trucking Jobs in 30 seconds
Every month 400 people find a job with the help of TruckersReport.
-
Did you use the ignition switch with the key when you started it or did you bypassed the ignition and went straight to the starter?
-
I bypassed the ignition and went straight to the starter. The truck starts and runs fine but it does not want to shut off, I have to disconnect the batteries and alternator.
-
-
Are there relays under the dash console that control sending the signal to the starter?
-
Is The starter replacement have a relay with the both coil ends isolate ? What by pass you did ? Is your truck is manual transmission or Volvo I Shift ?
-
Im a little teapot
Last edited: Aug 12, 2019
Reason for edit: Stupid samsuck crapaxy -
Do your gauges sweep and work when you key on? If so your fuses are probably good. But you may have more than one ignition fuse. I’d replace all for good measure. Next i would check at the ignition relay. Unplug the relay. Test for power going into the plug while someone turns the key. If your getting power to the relay, id change the relay. Halfway in this starter video (around the 4min mark) I talk about changing the relay on a gen1 vnl. Mine was on the outside firewall, drivers side.
Last edited: Aug 12, 2019
-
AModelCat Thanks this.
-
My phone screwed up. I posted it under my thread but it went here.
Trucking Jobs in 30 seconds
Every month 400 people find a job with the help of TruckersReport.
Page 1 of 2