You likely have an exhaust leak. Its either between the EPG housing and turbo, or turbo and manifold, or lastly manifold and head. Most of the...
One more thing to check. Take the trailer cord out of the socket on the tractor and make sure none of the pins are partially bridged with...
Have a tough problem in the shop. It is a 07 Volvo VNL D12. Driver hits a bump in the road and the ignition cuts out. Dash goes black. Engine...
Glad you got it sorted out.
No Problem, Let us know what you figure out.
There is no quick fix for it that will last. The most we get out of repairing that type of failure is about a year. The only way we have...
As others have said draining the system first is key. I also have a very nice set of tools to remove the airline from this type of fitting. They...
Hey Bowtie, Yes we did find the solution to our problem. The mechanic that did the install had installed the clutch incorrectly. I cant remember...
95% of our fleet uses the solo clutch. They are nice. No need for periodic adjustment. As for what they said, I do know that on the eaton...
That is why everyone is suggesting to you that the problem is in the back half of the trans. That is the part of the trans that shifts low to high.
If it grinds from low to high or high to low, its usually the back half needs to be rebuilt. Assuming the air supply is good. The XY wouldnt...
Does this model have the fusible link in between the starter and frame? That can cause serious problems, but that is on volvo with volvo engine.
I finally got the software to hook up to the tractor. It is a 2013 Volvo with version 3 electronics using OBD. I am trying to alter the roadspeed...
We did have one unusual tough truck vibration to diagnose a while back. Turned out to be a steering hub was bad. It was a hub pilot setup and the...
I have also used all of the major brands of tools for 25 years. Snap on tools for the most part are the best you can buy(with a few exceptions...
On ours it wasnt technically a recall...it was what they called an "updated" part. The difference being is if it is out of warranty they arent...
It definetly depends on the shop. But the initial one is usually to make sure everything is ok from the factory. At one time a few years back we...
As stated above it is an EPG. Its an air actuated plunger that restricts exhaust flow when turned on. To act as a brake or it also turns on when...
We have had some a couple of tractors do that. On ours the tractors idle would drop, then it would blow out a lot of black smoke, and then the epg...
Good luck with it. Hopefully it does the job. Its probably worth the risk of it for a fraction of the cost. I dont know what year your truck is...
