Truckers Report Jobs

Find Trucking Jobs

Company Driver Company Driver Dry Van Dry Van Flatbed Flatbed Refrigerated Refrigerated Specialized Specialized Owner Operator Owner Operator
More Trucking Job Searches ⌄ Fewer Trucking Job Searches
⌃

Kenworth W900 AC

Discussion in 'Trucks [ Eighteen Wheelers ]' started by Bdog, Jul 20, 2015.

  1. Jul 20, 2015 #1
    Bdog

    Bdog Road Train Member

    1,057
    877
    Nov 6, 2014
    0
    I have a 98 W900. The air coming out of the vents seems fairly cool but is barely blowing. Is there a cab air filter that might need to be cleaned or something else I could check?
     
    Bdog, Jul 20, 2015
    Bdog, Jul 20, 2015
    #1
  2. Truckers Report Jobs

    Trucking Jobs in 30 seconds

    Every month 400 people find a job with the help of TruckersReport.

  3. Jul 20, 2015 #2
    Superhauler

    Superhauler TEACHER OF MEN

    12,209
    100,729
    Jan 30, 2010
    keep stroking.
    0
    the evaporator may be plugged with dust. inside the a/c heater box.
     
    Superhauler, Jul 20, 2015
    Superhauler, Jul 20, 2015
    #2
  4. Jul 20, 2015 #4
    beemergary

    beemergary Light Load Member

    229
    112
    Apr 11, 2014
    0
    Is the fan going too HIGH
     
    beemergary, Jul 20, 2015
    beemergary, Jul 20, 2015
    #4
  5. Jul 21, 2015 #4
    Bdog

    Bdog Road Train Member

    1,057
    877
    Nov 6, 2014
    0
    Yes. When I switch it from low to high there is a slight difference but it is just weak. On low it is like it is not blowing at all you can barely feel it.

    How do you clean out the evaporater - from behind the glove box or under the hood? I looked at it breifly and it wasn't immediately obvious how to open it up.
     
    Bdog, Jul 21, 2015
    Bdog, Jul 21, 2015
    #4
  7. Jul 22, 2015 #5
    BigRik

    BigRik Bobtail Member

    46
    27
    May 12, 2015
    Houston, Tx
    0
    Look for a cabin filter if it has one kw usually have them under the air intake scoop on the side. If it doesnt have one look for the air box where the blower motor goes. Open it up clean the motor with some air pressure and gently clean out any gunk stuck on the the fins of the Cores i used a toothbrush, then rinsed it off with some low pressure water make sure the water has somewhere to go , small crack in the bottom should do. Seal it back up and youll be freezing your ### off in no time.
     
    BigRik, Jul 22, 2015
    BigRik, Jul 22, 2015
    #5
    Bdog Thanks this.
  8. Jul 22, 2015 #6
    Bdog

    Bdog Road Train Member

    1,057
    877
    Nov 6, 2014
    0
    Thanks. I opened up the box where the blower motor is and blew it and the evaporator out. Lots of dust but no major blockage. I did not see a filter on the side. It seems slightly better but not much. On high I would say it is equivalent to my pickup on low. I will keep digging. It has been raining the past few weeks and now it is dry the phone is ringing off the hook for us to haul dirt. Really don't have a lot of time to fool with it as I am trying to get while the getting is good.
     
    Bdog, Jul 22, 2015
    Bdog, Jul 22, 2015
    #6
  9. Jul 23, 2015 #7
    BigRik

    BigRik Bobtail Member

    46
    27
    May 12, 2015
    Houston, Tx
    0
    I hear ya, you hauling an end dump?You said there was alot of dust. If your truck is anything like mine 2007 kw t600 it has the blower motor stuck on the top panel and has a steel plate with a small motor for the vent and a thermostat stick. If your truck is similar did you take that plate out?
     
    BigRik, Jul 23, 2015
    BigRik, Jul 23, 2015
    #7
  • Truckers Report Jobs

    Trucking Jobs in 30 seconds

    Every month 400 people find a job with the help of TruckersReport.